P0431 on Nissan: How to Diagnose & Fix
Warm Up Catalyst Efficiency Below Threshold (Bank 2)
1 Nissan model · 1 documented issue · 1 critical · $900-$3,500 repair
P0431 on Nissan by model: symptoms, diagnosis and fix
The TA60 runs close-coupled converters bolted to the manifolds plus secondary converters downstream. Owners repeatedly report the ceramic substrate in an upstream converter breaking apart, at which point the loose material blows downstream and packs the secondary converter, choking the exhaust. Symptoms progress from a P0420/P0430 efficiency code to a rattle from the exhaust, then to a truck that will not pull, runs hot, and feels like it has lost half its power because it cannot exhale. Because the same codes are also set by lazy oxygen sensors, plenty of owners replace sensors first and are surprised when the codes come back.
Common Symptoms
- Check engine light with P0420 and/or P0430
- Severe loss of power at higher RPM
- Rattling from under the vehicle
- Rotten egg or sulfur smell
- Poor fuel economy
- Exhaust glowing or unusually hot
- Engine stalls or will not rev under load
How to Fix
Before condemning converters, check upstream/downstream O2 sensor switching on a scan tool and rule out an exhaust leak - a cracked manifold or leaking flange upstream of the rear sensor will set the same code with good converters. If the converter is genuinely dead, confirm with a backpressure test or by tapping the housing to hear loose substrate. Replace the failed converter and inspect the downstream converter for packed debris - replacing only the upstream unit leaves the clog. On the driver's side the engine typically has to be raised at the mounts to get the converter out. Fix any upstream cause (misfire, oil consumption, rich condition) or the new converter dies the same way.
Sources for this issue (4)
- Armada catalytic converter issues... anybody having them? | Nissan Armada & Infiniti QX56 Forumsforum
- Please Help 04 armada with codes P0420 & P0430 | Nissan Armada & Infiniti QX56 Forumsforum
- P0420 and P0430 | Nissan Armada & Infiniti QX56 Forumsforum
- Codes P0420 & P0430 V8 catalytic converter issues | Nissan Forumsforum
P0431 code reference
General diagnostic-code context. The code alone does not confirm a cause for your vehicle; use the applicable issue card and its sources.
Frequently asked questions
What does P0431 mean on a Nissan?
P0431 stands for "Warm Up Catalyst Efficiency Below Threshold (Bank 2)." On vehicles with a primary/warm-up catalyst, the PCM determines the Bank 2 warm-up catalyst (WU-TWC) is below its efficiency threshold, based on the upstream/downstream O2 sensor comparison for that bank. On Nissan it is documented across 1 model: Armada.
What are the most common causes of P0431?
The most common causes of P0431 are: Worn/failed Bank 2 warm-up catalytic converter, Aged or contaminated O2 sensor on Bank 2, Exhaust leak near the warm-up catalyst, Misfire or improper air/fuel on Bank 2, Oil/coolant contamination. The specific cause varies by vehicle.
How much does it cost to fix P0431 on a Nissan?
Published repair estimates on Nissan range from $900 to $3,500 depending on the model and root cause. If an issue mentions a recall or campaign, check your VIN with the manufacturer or NHTSA and confirm eligibility and coverage with a dealer.
Looking for P0431 on a different make?
View P0431 across all makes →Content compiled with AI assistance using NHTSA complaints, TSBs, and owner reports. May contain errors. Always verify with your vehicle's service manual.