P0598 on MINI: How to Diagnose & Fix
Thermostat Heater Control Circuit Low
1 MINI model · 1 documented issue · 1 critical · $400-$1,200 repair
P0598 on MINI by model: symptoms, diagnosis and fix
Both R56 and early F56 Coopers use an electric thermostat housing and electric water pump that are prone to premature failure. The thermostat housing cracks causing coolant leaks, and the water pump impeller can fail leading to overheating.
Common Symptoms
- Coolant warning light
- Overheating
- Coolant puddle under car
- Heater blowing cold air
- Temperature gauge fluctuation
How to Fix
Replace thermostat housing assembly and/or electric water pump. Use updated MINI parts. The thermostat housing is on the front of the engine and relatively accessible. Water pump is belt-driven on N12/N16, electric on newer B38/B48.
What you need to fix it
Only diagnosis- and fitment-reviewed repair parts are linked here.
- Saleri MINI water pump 11517648827OEMSaleri PA1425 / MINI 11517648827
Confirm VIN, engine and current interchange before purchase; this is not an el
- Mahle MINI thermostat assembly 11538699290OEMMahle TM57105 / MINI 11538699290
R56 N12/N14 and VIN-confirmed N16 thermostat-housing branch Fitment/availability: The inspected direct U.S. Confirm VIN, engine, production date and connector; do not use for an N18 or
- Rein MINI thermostat housing 11538674895OEMRein CTA0051 / MINI 11538674895
R56 N18 and VIN-confirmed later N16 thermostat-housing branch Fitment/availability: The inspected direct U.S. Use only after VIN, engine and connector verification confirms the N18-style branch; do not infer it from
As an Amazon Associate, we earn from qualifying purchases; other part links may also earn au7o a commission. Confirm fitment by VIN before buying.
P0598 code reference
General diagnostic-code context. The code alone does not confirm a cause for your vehicle; use the applicable issue card and its sources.
Frequently asked questions
What does P0598 mean on a MINI?
P0598 stands for "Thermostat Heater Control Circuit Low." This code applies to engines with an electronically controlled (heated) thermostat and means the Powertrain Control Module detected an abnormally low voltage in the thermostat heater control circuit. The heater element lets the computer fine-tune coolant temperature for efficiency and emissions by opening the thermostat sooner under certain conditions. P0598 sets when the control or feedback circuit reads lower than expected (often a short to ground or loss of supply). It is found mainly on certain European makes (BMW, Mercedes, VW/Audi, etc.) and usually has little effect on driving. On MINI it is documented across 1 model: Cooper.
What are the most common causes of P0598?
The most common causes of P0598 are: Faulty electronically controlled (map-controlled) thermostat, Short to ground in the heater control wiring, Corroded or loose thermostat connector, Open or damaged wiring in the control circuit, Low coolant level overheating the thermostat heater, Blown fuse or poor power supply to the circuit, Faulty PCM control driver. The specific cause varies by vehicle.
How much does it cost to fix P0598 on a MINI?
Published repair estimates on MINI range from $400 to $1,200 depending on the model and root cause. If an issue mentions a recall or campaign, check your VIN with the manufacturer or NHTSA and confirm eligibility and coverage with a dealer.
Looking for P0598 on a different make?
View P0598 across all makes →Content compiled with AI assistance using NHTSA complaints, TSBs, and owner reports. May contain errors. Always verify with your vehicle's service manual.