2011-2016 model years · 60+ owner reports · Updated May 2026
According to Au7o's analysis of 60+ owner reports, the 2011-2016 Honda CR-Z has 3 documented known issues, with 1 rated critical. The most serious is IMA Hybrid Battery Pack Degradation and Recalibration Issues ($1,000-$3,000 repair). Across all issues, repair costs range from $150 to $3,000. DIY maintenance guides at au7o.io.
On the 2011-2016 Honda CR-Z 1.5L, the CR-Z uses Honda Integrated Motor Assist (IMA) system with a nickel-metal hydride (NiMH) battery pack located behind the rear seats. The battery pack degrades over time, losing capacity and causing the IMA system to become less effective at assisting acceleration and regenerating energy. The battery management system can also lose its calibration, causing incorrect state-of-charge readings and frequent IMA warning lights. In severe degradation, the IMA system shuts down entirely, leaving the car running on the 1.5L engine alone.
Perform a battery recalibration (deep discharge and full recharge cycle) using a Honda diagnostic tool. If recalibration does not resolve the issue, replace the IMA battery pack — Honda OEM replacements are available, and aftermarket rebuilt packs cost $1,000-2,000 less. Companies like Bumblebee Batteries offer refurbished IMA packs with warranties. After battery replacement, reset the battery module ECU and allow the system to relearn over 2-3 drive cycles.
Parts and tips from 0+ owners who fixed this issue
On the 2011-2016 Honda CR-Z, the CR-Z uses a compact A/C compressor that experiences clutch bearing failure and clutch plate wear. The compressor is mounted low in the engine bay where it is exposed to water splash, accelerating bearing corrosion. The small compressor works hard in the CR-Z's compact engine bay where underhood temperatures run high. A seized compressor clutch bearing creates a loud squealing noise and can shred the serpentine belt if not addressed.
Replace the compressor clutch bearing and clutch plate if caught early ($150-300). If the compressor has seized internally, replace the entire compressor assembly. Replace the A/C receiver-drier and expansion valve during the repair. Evacuate the system, pull a vacuum for 30+ minutes to remove moisture, and recharge with the correct amount of R-134a refrigerant.
Parts and tips from 60+ owners who fixed this issue
On the 2011-2016 Honda CR-Z, the CR-Z with the 6-speed manual transmission (the enthusiast choice) develops clutch slave cylinder failures. The internal seal deteriorates, causing hydraulic fluid to leak past the piston. This results in a spongy clutch pedal feel, difficulty getting into gear, and eventually a clutch pedal that sinks to the floor. The master cylinder can also fail but the slave cylinder is far more common. Because the slave cylinder is externally mounted on the CR-Z (not internal to the bell housing), replacement is relatively straightforward.
Replace the clutch slave cylinder with a new OEM Honda unit. Bleed the clutch hydraulic system thoroughly — use DOT 3 brake fluid as specified. Inspect the clutch master cylinder for leaks while the system is open. If the clutch fluid is dark or contaminated, flush the entire system. The clutch line from master to slave should also be inspected for deterioration. While the slave cylinder is accessible, inspect the clutch fork pivot and release bearing for wear.
Parts and tips from 0+ owners who fixed this issue
AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE
Honda (American Honda Motor Co.) is recalling certain 2013 Acura ILX, 2015 RDX, 2005-2010 and 2012 RL, 2009-2014 TL, 2010 and 2012 ZDX, 2007-2011 CR-V, 2011-2013 and 2015 CR-Z, 2009-2013 Fit, 2013 Fit EV, 2010-2011 and 2013 Insight and 2007-2014 Ridgeline vehicles. These vehicles are equipped with driver frontal air bag inflators assembled as a recall remedy part or replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE
Honda (American Honda Motor Co.) is recalling certain model year 2007-2011 Honda CR-V, 2011-2015 CR-Z, 2010-2014 FCX, and Insight, 2009-2013 Fit, 2013-2014 Fit EV, 2007-2014 Ridgeline, 2013-2016 Acura ILX, 2013-2014 Acura ILX Hybrid, 2007-2016 RDX, 2005-2012 Acura RL, 2009-2014 Acura TL, and 2010-2013 Acura ZDX vehicles. The affected vehicles are equipped with a dual-stage driver frontal air bag that may be susceptible to moisture intrusion which, over time, could cause the inflator to rupture.
Enter your VIN at NHTSA.gov to check recalls specific to your vehicle.
Don't see your problem? Describe your symptoms to get a diagnosis, or get a full repair guide.
According to Au7o's analysis of 60+ owner reports, the 2011-2016 Honda CR-Z has 3 documented issues. The most frequently reported are: IMA Hybrid Battery Pack Degradation and Recalibration Issues, A/C Compressor Clutch and Bearing Failure, Manual Transmission Clutch Slave Cylinder Failure. Of these, 1 is rated critical and should be addressed promptly.
The 2011-2016 Honda CR-Z has 3 known issues documented across 60+ owner reports. 1 issue is rated critical: IMA Hybrid Battery Pack Degradation and Recalibration Issues. Prospective buyers should inspect for these issues and factor potential repair costs into their purchase decision. Regular maintenance following the manufacturer's schedule helps prevent many common problems.
Repair costs for known Honda CR-Z issues range from $150 to $3,000, depending on the specific problem and whether you choose DIY or professional repair. The most critical issue, IMA Hybrid Battery Pack Degradation and Recalibration Issues, typically costs $1,000-$3,000 to repair. Au7o provides step-by-step DIY maintenance guides that can help reduce repair costs.
Reliability varies across model years of the Honda CR-Z. Based on documented issues, problems are most commonly reported in earlier model years. Au7o recommends checking the specific known issues for your target year before purchasing, and having a pre-purchase inspection performed by a qualified mechanic. Our known issues database covers the 2011-2016 Honda CR-Z with 3 documented issues documented across 60+ owner reports.
The CR-Z uses Honda Integrated Motor Assist (IMA) system with a nickel-metal hydride (NiMH) battery pack located behind the rear seats. The battery pack degrades over time, losing capacity and causing the IMA system to become less effective at assisting acceleration and regenerat… Repairs typically run $1,000-$3,000. Severity: high.
The CR-Z uses a compact A/C compressor that experiences clutch bearing failure and clutch plate wear. The compressor is mounted low in the engine bay where it is exposed to water splash, accelerating bearing corrosion. The small compressor works hard in the CR-Z's compact engine… Repairs typically run $150-$1,000. Severity: medium.
The CR-Z with the 6-speed manual transmission (the enthusiast choice) develops clutch slave cylinder failures. The internal seal deteriorates, causing hydraulic fluid to leak past the piston. This results in a spongy clutch pedal feel, difficulty getting into gear, and eventually… Repairs typically run $200-$500. Severity: medium.
Content on this page was compiled with AI assistance using NHTSA complaints, TSBs, owner reports, and public automotive data. While we strive for accuracy, this information may contain errors. Always verify repair procedures and specifications with your vehicle's service manual or a qualified mechanic.
