2022 Lucid Air Problems: 12 Known Issues

On the 2022-2023 Lucid Air, the main high-voltage battery contactors on early Air production can snap back to the open position while the vehicle is in motion, instantly cutting power from the pack to the drive motors. Lucid traced the original defect to contactors built with a return spring too strong for the contactor's magnetic holding force: the spring force can overcome the magnetic hold, which shows up in the contactor current signature as a characteristic double-dip. Cars showing a double-dip on at least five percent of closures were judged to present a safety risk. The initial campaign 23V110 covered cars built October 2021 - November 2022 at Casa Grande (637 in the March 2023 filing; NHTSA's record now lists 886), and Lucid's analysis identified 232 that needed physical contactor replacement. A separate campaign, 24V497, covers 5,251 2022-2023 Air vehicles built through November 2022 in which intermittent wiring-connection faults could make the High Voltage Interlock (HVIL) software open the contactors while driving.

On the 2022 Lucid Air, on 2022 Air vehicles built before the 4 May 2022 clean point - effectively every Air produced to that date, 1,117 units - the left and center display wiring harness was routed without sufficient clearance from the steering intermediate shaft. The rotating shaft chafes the harness, and once through the insulation the display screens shut off entirely. That takes the speedometer, gear selection indicator and telltale warning lights with them, which is why NHTSA treated it as an FMVSS 101 (Controls and Displays) noncompliance rather than a convenience defect. This is a physical routing and chafe fault and is distinct from the software-side display freezes seen on early production.

On the 2022-2024 Lucid Air, a software defect present in Lucid vehicle software releases 2.1.2 through 2.1.26 can cause a sudden loss of drive power under a specific and repeatable ACC interaction sequence: adaptive cruise control is active, the car detects an obstacle and decelerates, the driver then accelerates to override ACC, and the driver subsequently cancels ACC either with the ACC button or by braking. The resulting state can drop motive power without warning. Approximately 189 Air vehicles were in the affected software population. This is a control-software fault, not a hardware or high-voltage failure, and it is distinct from the contactor and inverter power-loss campaigns.

On the 2022-2024 Lucid Air all, lucid Air owners report the 12V auxiliary system (two AGM 12V batteries) going flat or faulting, leaving the car unable to wake or shutting it down shortly after a 12V battery warning. Owner reports point to the 12V batteries, the 12V charging path from the high-voltage pack, or a high-voltage communication fault rather than one confirmed cause. Pattern consistent with other premium EVs. Software updates have reduced parasitic draw but the issue persists for some owners.

On the 2022-2024 Lucid Air, owners of early-production Lucid Air cars report frequent infotainment freezing, slow boot times, glitches with CarPlay (since added via update), and unresponsive Pilot Panel (the smaller lower screen used for touch HVAC and camera controls). Multiple OTA updates have improved this, but the problem persists on some cars.

On the 2022-2024 Lucid Air all, lucid Air charge-port LED ring (which displays charging state via color) can fail to display correctly — sometimes showing wrong color, flickering, or going dark while still actively charging. Cosmetic-only in most cases (charging still works), but confusing for owners trying to verify session state.

On the 2022-2024 Lucid Air, lucid issued recall SR-24-04-0 (NHTSA 24V495) in mid-2024 covering 2022-2024 Lucid Air vehicles for high voltage coolant heater (HVCH) failure — the Webasto AG-supplied HVCH could suffer internal delamination, causing failure to defrost the windshield and loss of cabin heat in cold weather. It expands the earlier 24V011 (SR-24-01-0) recall to all US cars with heaters built before February 2023. Owner notification letters were mailed August 5, 2024.

On the 2022-2026 Lucid Air, owners consistently report DreamDrive applying the brakes for obstacles that are not there, on both Highway Assist / Drive Assist and plain adaptive cruise control. The dominant trigger pattern in owner reports is passing large vehicles - 18-wheelers with trailers and RVs - with one owner putting the rate at roughly 30 percent of overtakes on the right side; overpasses are the other repeated trigger. Severity ranges from a brief audio alert with a mild slowdown up to a hard brake application accompanied by a collision alert, which owners describe as a rear-end risk that makes the cruise control effectively unusable on some routes. Behavior is strongly software-version dependent and has moved in both directions across OTA releases: some owners reported their overpass and semi-truck events disappeared entirely on 2.8.0, while others reported the same release made the system more sensitive and highway driving more stressful. That version-dependence is the practical signature of this issue and distinguishes it from a hardware sensor fault.

On the 2022-2026 Lucid Air, two separate software-caused rear visibility noncompliances have hit the Air. Under 25V670, cars running software prior to 2.8.0 could have the lower console display fail to show the rearview camera image at all; cars with the first-generation Center Console Controller (CCCv1) and the AD02 package running software older than 2.7.1 could also show a delayed and inaccurate image of what is behind the vehicle - which is worse than no image because the driver acts on stale video. Under 26V017, a defect introduced with software 2.8.0 and present through 2.8.16 affects cars equipped with the AD02 package: the Autonomous Control Unit, coming out of a sleep state under increased compute load, can in limited instances fail to supply the rearview image when the vehicle is shifted into reverse. Both were filed as FMVSS 111 Rear Visibility noncompliances.

On the 2022 Lucid Air, lucid's first-ever recall. Suspension supplier Thyssenkrupp Bilstein shipped front damper assemblies with the snap ring below the front damper lower spring seat installed upside down. Inverted, the ring cannot carry the loads the suspension applies to it and can fail at between roughly 4 and 44 percent of its intended service life. A failed snap ring lets the spring seat move, producing a sudden drop in ride height, vehicle vibration, and potential damage to the front brake line running nearby - a brake-system consequence, not just a ride-quality one. 203 model year 2022 Air vehicles were affected. Lucid reported no field failures at the time of the campaign, which is consistent with this being caught early through supplier audit rather than owner complaints.

On the 2022-2024 Lucid Air all, lucid Air owners report wind noise, in some cases traced by service to a poor glass canopy roof seal — pattern in early production but present across years. Owner service visits more often trace highway wind noise to door and window alignment or door seals, so the roof is not always the source. The single-piece glass roof creates a tight tolerance challenge that some VINs ship outside of spec.

On the 2022-2023 Lucid Air, owners of early Lucid Air cars (particularly Dream Edition cars built during the AMP-1 production ramp at Casa Grande, AZ) report paint orange-peel, dust inclusions, and color match issues across panels. Manufacturing quality improved across 2023; Lucid has repainted severe cases.