2023 Volvo XC40 Recharge Problems: 5 Known Issues

On the 2023-2025 Volvo XC40 Recharge, a brake control module software defect introduced by an earlier over-the-air update means that coasting downhill in a regenerative mode with no pedal input can disable the hydraulic brake function entirely. Specifically, if the vehicle is in One Pedal Drive (BEV) and coasts downhill for at least about 1 minute 30 seconds (Volvo's amended recall report; its original report said 1 minute 40 seconds) with neither the accelerator nor the brake pedal touched, brake assist can fail. Pressing the brake pedal afterward may not restore braking. NHTSA issued an unusual public advisory telling owners to stop using One Pedal Drive until the update was applied. Campaign 25V-392 covers 11,469 Volvo BEV and PHEV vehicles including the XC40 BEV. The defect was itself a regression introduced by the fix for the rearview camera campaign 25V-282.

On the 2021-2024 Volvo XC40 Recharge, separate from and outliving the 2021-2022 accelerator pedal sensor recall, roughly 100 owners have reported the XC40 Recharge lurching, jumping, or surging without warning — most often at low speed, during shifts between drive and reverse, or while using One Pedal Drive. A class action filed June 25, 2025 alleges a defect in the powertrain control system across 2021-2024 XC40 Recharge vehicles and contends that the two existing recalls were too narrow in scope to address it, leaving later model years uncovered. Forum reports include at least one collision attributed to the behavior. Volvo has not conceded a defect covering the full year range, so there is currently no free remedy for cars outside recall 22V-288.

On the 2021-2025 Volvo XC40 Recharge, the XC40 Recharge was one of the first vehicles to ship with Google built-in / Android Automotive as the native infotainment OS rather than a projection layer. Owners across model years report the center display locking up — touch input does nothing, audio cuts out, navigation and media stop responding — often after a software update, after a cold soak, or when a phone Bluetooth session goes bad. Some cars run correctly for a few days after a dealer system reload and then freeze again while in motion. Because climate control and drive-mode selection live inside the same screen, a freeze removes access to core vehicle functions, not just entertainment. This is a distinct complaint from the recalled rearview camera fault, though both stem from the same infotainment stack.

On the 2021-2025 Volvo XC40 Recharge, the most frequently reported ownership problem on the XC40 Recharge is a dead 12V auxiliary battery after the car has sat parked. The high-voltage pack is normally full, but the 12V system drops below the threshold needed to close the contactors, so the car is completely inert — no unlock, no display, no ability to start. Owners and Volvo service departments trace this to two things: parasitic drain from telematics wake-ups (the Volvo Cars app polling the vehicle, or a key fob left within range keeping modules awake), and, in a subset of cars, a defective DC-DC converter that fails to top the 12V battery from the traction pack. The DC-DC converter performs the alternator's job in this vehicle, so when it underperforms the 12V battery is never properly replenished even during driving.

On the 2021-2025 Volvo XC40 Recharge, a software fault in the infotainment/camera pipeline can leave the rearview camera image absent when the transmission is placed in reverse, leaving the driver with no view behind the vehicle. This violates Federal Motor Vehicle Safety Standard 111 (Rear Visibility). The fault has required two distinct campaigns on the XC40 Recharge — 25V-282 and then 25V-908 — both covering 2021-2025 model year cars, indicating the first software remedy did not fully resolve it. The 25V-282 remedy is also the update that introduced the separate brake-assist defect later recalled as 25V-392, so vehicles in this window may need multiple software actions.